L592 EVN formerly J2 CXM
-
- Knows how to use the parking brake
- Posts: 151
- Joined: Tue Apr 05, 2022 6:59 pm
- Orga / RP numbers: RP6043
Re: My new project
replaced the fuel filter and housing today
easy job, primed up fine, runs better too! no leaks either
easy job, primed up fine, runs better too! no leaks either
-
- Knows how to use the parking brake
- Posts: 151
- Joined: Tue Apr 05, 2022 6:59 pm
- Orga / RP numbers: RP6043
Re: My new project
special little moment today driving this
i was joined on a dual carriageway by a lovely silver C6!!
2.2 too! so rare
waves and thumbs up were exchanged
i was joined on a dual carriageway by a lovely silver C6!!
2.2 too! so rare
waves and thumbs up were exchanged
-
- Knows how to use the parking brake
- Posts: 151
- Joined: Tue Apr 05, 2022 6:59 pm
- Orga / RP numbers: RP6043
Re: My new project
some more progression
Horrible aftermarket tweeters removed from the top of the dash, sadly screwed in but have thankfully the dash is soft up there so should be able to sort it
more aftermarket wiring removed, i think that's about all of it as far as i'm aware
also got the spare wheel down, all tools are present except the wheel brace of course.....original tyre too a Michelin MXL
please see attached the recent photos, as well as a little photo shoot the other day
Horrible aftermarket tweeters removed from the top of the dash, sadly screwed in but have thankfully the dash is soft up there so should be able to sort it
more aftermarket wiring removed, i think that's about all of it as far as i'm aware
also got the spare wheel down, all tools are present except the wheel brace of course.....original tyre too a Michelin MXL
please see attached the recent photos, as well as a little photo shoot the other day
You do not have the required permissions to view the files attached to this post.
-
- Knows how to use the parking brake
- Posts: 151
- Joined: Tue Apr 05, 2022 6:59 pm
- Orga / RP numbers: RP6043
Re: My new project
she looks good!
You do not have the required permissions to view the files attached to this post.
-
- Knows how to use the parking brake
- Posts: 151
- Joined: Tue Apr 05, 2022 6:59 pm
- Orga / RP numbers: RP6043
Re: My new project
still no blower, suspect it's siezed, may well take it out tomorrow and inspect it
drivers window regulator still needs replacing, i must admit i've been putting that off as no doubt it will be a faff on
also, no remote locking....it did work, sometimes when the alarm panel was in place but since i removed it nothing from it at all
no interior lights, this is due to a fire in the wiring and it's all charred.....need to think about that at some point
no sunroof openage, probably for the best with how the seals look
drivers window regulator still needs replacing, i must admit i've been putting that off as no doubt it will be a faff on
also, no remote locking....it did work, sometimes when the alarm panel was in place but since i removed it nothing from it at all
no interior lights, this is due to a fire in the wiring and it's all charred.....need to think about that at some point
no sunroof openage, probably for the best with how the seals look
-
- Global Moderator
- Posts: 13818
- Joined: Thu Jun 18, 2009 6:44 pm
Re: My new project
The window regulator is easy, lower the window 3/4 and reach round the lower edge of the glass and unclip the C ring holding the plastic block together, then lift the glass and jam it with a couple of clothes-pegs as wedges.
there are three nuts on the regulator and two on the slider mechanism, then the unit pulls out.
I have seen corrosion on the motor connector cause failed operation.
the sunrood outer seal has nothing to do with excluding wter, so if it's not leaking just work on freeing it off and diagnosing any electrical failure.
There is a relay and two micro-switches on the mtor, then the open/closed switch.
Sometimes operating the motor while turning the cable drive with an allen key, can free off a seized unit.
there are three nuts on the regulator and two on the slider mechanism, then the unit pulls out.
I have seen corrosion on the motor connector cause failed operation.
the sunrood outer seal has nothing to do with excluding wter, so if it's not leaking just work on freeing it off and diagnosing any electrical failure.
There is a relay and two micro-switches on the mtor, then the open/closed switch.
Sometimes operating the motor while turning the cable drive with an allen key, can free off a seized unit.
92 2.1SED M.RP5740 ECZ Sable Phenicien
92 3.0 V6-24.Rp 5713 EXY Black
92 2.1SD M.RP 5685 ENT Blue Sideral
Prev
90 2.1SD M.RP 5049 EJV Mandarin
92 2.1SD A.RP 5698 EJV Mandarin
94 2.1SD A.RP 6218 ERT Triton Green
91 2.0SI M.RP 5187 EWT White
92 3.0 V6-24.Rp 5713 EXY Black
92 2.1SD M.RP 5685 ENT Blue Sideral
Prev
90 2.1SD M.RP 5049 EJV Mandarin
92 2.1SD A.RP 5698 EJV Mandarin
94 2.1SD A.RP 6218 ERT Triton Green
91 2.0SI M.RP 5187 EWT White
-
- Knows how to use the parking brake
- Posts: 151
- Joined: Tue Apr 05, 2022 6:59 pm
- Orga / RP numbers: RP6043
Re: My new project
it's rather difficult to lower the window without it operating
i will have to pop off the door card and see what i'm faced with, it's a job i may well attempt in the coming days as it would be rather nice
even to go through drive through's etc
sunroof i'm not bothering with for now, it's at the bottom of the list of stuff to do
i will have to pop off the door card and see what i'm faced with, it's a job i may well attempt in the coming days as it would be rather nice
even to go through drive through's etc
sunroof i'm not bothering with for now, it's at the bottom of the list of stuff to do
-
- Global Moderator
- Posts: 13818
- Joined: Thu Jun 18, 2009 6:44 pm
Re: My new project
The procedure is the same, but prising the glass off the nylon stud is harder due to the window guide being stiffer near the mountings.maxferreira wrote: ↑Fri Jun 17, 2022 1:04 pmit's rather difficult to lower the window without it operating
The car is trying to tell you something...maxferreira wrote: ↑Fri Jun 17, 2022 1:04 pmi will have to pop off the door card and see what i'm faced with, it's a job i may well attempt in the coming days as it would be rather nice
even to go through drive through's etc
92 2.1SED M.RP5740 ECZ Sable Phenicien
92 3.0 V6-24.Rp 5713 EXY Black
92 2.1SD M.RP 5685 ENT Blue Sideral
Prev
90 2.1SD M.RP 5049 EJV Mandarin
92 2.1SD A.RP 5698 EJV Mandarin
94 2.1SD A.RP 6218 ERT Triton Green
91 2.0SI M.RP 5187 EWT White
92 3.0 V6-24.Rp 5713 EXY Black
92 2.1SD M.RP 5685 ENT Blue Sideral
Prev
90 2.1SD M.RP 5049 EJV Mandarin
92 2.1SD A.RP 5698 EJV Mandarin
94 2.1SD A.RP 6218 ERT Triton Green
91 2.0SI M.RP 5187 EWT White
-
- Knows how to use the parking brake
- Posts: 151
- Joined: Tue Apr 05, 2022 6:59 pm
- Orga / RP numbers: RP6043
Re: My new project
really pushed the boundaries today
wanted to see how the waterproofing was.....decided to pop it through an automatic car wash!
it's done an annoyingly good job too
conclusion......slight drip from a door seal, that's it
paintwork really isn't the best, it looks presentable for sure but has a fair few marks so i'm not worried about car washes etc
wanted to see how the waterproofing was.....decided to pop it through an automatic car wash!
it's done an annoyingly good job too
conclusion......slight drip from a door seal, that's it
paintwork really isn't the best, it looks presentable for sure but has a fair few marks so i'm not worried about car washes etc
-
- Knows how to use the parking brake
- Posts: 151
- Joined: Tue Apr 05, 2022 6:59 pm
- Orga / RP numbers: RP6043
Re: My new project
remote locking was a very easy fix
put new batteries in and it works fine
put new batteries in and it works fine